14 C.F.R. §§ 27.1541–27.1589

§27.1541. General.

14 C.F.R. § 27.1541

(a)

The rotorcraft must contain—

(1)

The markings and placards specified in §§ 27.1545 through 27.1565, and

(2)

Any additional information, instrument markings, and placards required for the safe operation of rotorcraft with unusual design, operating or handling characteristics.

(b)

Each marking and placard prescribed in paragraph (a) of this section—

(1)

Must be displayed in a conspicuous place; and

(2)

May not be easily erased, disfigured, or obscured.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

§27.1543. Instrument markings: general.

14 C.F.R. § 27.1543

For each instrument—

(a)

When markings are on the cover glass of the instrument, there must be means to maintain the correct alignment of the glass cover with the face of the dial; and

(b)

Each arc and line must be wide enough, and located, to be clearly visible to the pilot.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

§27.1545. Airspeed indicator.

14 C.F.R. § 27.1545

(a)

Each airspeed indicator must be marked as specified in paragraph (b) of this section, with the marks located at the corresponding indicated airspeeds.

(b)

The following markings must be made:

(1)

A red line—

(i)

For rotorcraft other than helicopters, at VNE.

(ii)

For helicopters, at VNE (power-on).

(iii)

For helicopters, at VNE (power-off). If VNE (power-off) is less than VNE (power-on) and both are simultaneously displayed, the red line at VNE (power-off) must be clearly distinguishable from the red line at VNE (power-on).

(2)

[Reserved]

(3)

For the caution range, a yellow range.

(4)

For the normal operating range, a green or unmarked range.

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-14, 43 FR 2325, Jan. 16, 1978; 43 FR 3900, Jan. 30, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-14, 43 FR 2325, Jan. 16, 1978; 43 FR 3900, Jan. 30, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

§27.1547. Magnetic direction indicator.

14 C.F.R. § 27.1547

(a)

A placard meeting the requirements of this section must be installed on or near the magnetic direction indicator.

(b)

The placard must show the calibration of the instrument in level flight with the engines operating.

(c)

The placard must state whether the calibration was made with radio receivers on or off.

(d)

Each calibration reading must be in terms of magnetic heading in not more than 45 degree increments.

(e)

If a magnetic nonstabilized direction indicator can have a deviation of more than 10 degrees caused by the operation of electrical equipment, the placard must state which electrical loads, or combination of loads, would cause a deviation of more than 10 degrees when turned on.

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-13, 42 FR 36972, July 18, 1977]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-13, 42 FR 36972, July 18, 1977]

§27.1549. Powerplant instruments.

14 C.F.R. § 27.1549

For each required powerplant instrument, as appropriate to the type of instrument—

(a)

Each maximum and, if applicable, minimum safe operating limit must be marked with a red line;

(b)

Each normal operating range must be marked as a green or unmarked range;

(c)

Each takeoff and precautionary range must be marked with a yellow range or yellow line;

(d)

Each engine or rotor range that is restricted because of excessive vibration stresses must be marked with red ranges or red lines; and

(e)

Each OEI limit or approved operating range must be marked to be clearly differentiated from the markings of paragraphs (a) through (d) of this section except that no marking is normally required for the 30-second OEI limit.

Notes, amendments, and revision history

Amendments

[Amdt. 27-11, 41 FR 55470, Dec. 20, 1976, as amended by Amdt. 27-23, 53 FR 34215, Sept. 2, 1988; Amdt. 27-29, 59 FR 47768, Sept. 16, 1994; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Amdt. 27-11, 41 FR 55470, Dec. 20, 1976, as amended by Amdt. 27-23, 53 FR 34215, Sept. 2, 1988; Amdt. 27-29, 59 FR 47768, Sept. 16, 1994; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

§27.1551. Oil quantity indicator.

14 C.F.R. § 27.1551

Each oil quantity indicator must be marked with enough increments to indicate readily and accurately the quantity of oil.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

§27.1553. Fuel quantity indicator.

14 C.F.R. § 27.1553

If the unusable fuel supply for any tank exceeds one gallon, or five percent of the tank capacity, whichever is greater, a red arc must be marked on its indicator extending from the calibrated zero reading to the lowest reading obtainable in level flight.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

§27.1555. Control markings.

14 C.F.R. § 27.1555

(a)

Each cockpit control, other than primary flight controls or control whose function is obvious, must be plainly marked as to its function and method of operation.

(b)

For powerplant fuel controls—

(1)

Each fuel tank selector control must be marked to indicate the position corresponding to each tank and to each existing cross feed position;

(2)

If safe operation requires the use of any tanks in a specific sequence, that sequence must be marked on, or adjacent to, the selector for those tanks; and

(3)

Each valve control for any engine of a multiengine rotorcraft must be marked to indicate the position corresponding to each engine controlled.

(c)

Usable fuel capacity must be marked as follows:

(1)

For fuel systems having no selector controls, the usable fuel capacity of the system must be indicated at the fuel quantity indicator unless it is:

(i)

Provided by another system or equipment readily accessible to the pilot; and

(ii)

Contained in the limitations section of the rotorcraft flight manual.

(2)

For fuel systems having selector controls, the usable fuel capacity available at each selector control position must be indicated near the selector control.

(d)

For accessory, auxiliary, and emergency controls—

(1)

Each essential visual position indicator, such as those showing rotor pitch or landing gear position, must be marked so that each crewmember can determine at any time the position of the unit to which it relates; and

(2)

Each emergency control must be red and must be marked as to method of operation.

(e)

For rotorcraft incorporating retractable landing gear, the maximum landing gear operating speed must be displayed in clear view of the pilot.

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-11, 41 FR 55470, Dec. 20, 1976; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-11, 41 FR 55470, Dec. 20, 1976; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984; Amdt. 27-51, 88 FR 8738, Feb. 10, 2023]

§27.1557. Miscellaneous markings and placards.

14 C.F.R. § 27.1557

(a)

Baggage and cargo compartments, and ballast location. Each baggage and cargo compartment, and each ballast location must have a placard stating any limitations on contents, including weight, that are necessary under the loading requirements.

(b)

Seats. If the maximum allowable weight to be carried in a seat is less than 170 pounds, a placard stating the lesser weight must be permanently attached to the seat structure.

(c)

Fuel and oil filler openings. The following apply:

(1)

Fuel filler openings must be marked at or near the filler cover with—

(i)

The word “fuel”;

(ii)

For reciprocating engine powered rotorcraft, the minimum fuel grade;

(iii)

For turbine engine powered rotorcraft, the permissible fuel designations; and

(iv)

For pressure fueling systems, the maximum permissible fueling supply pressure and the maximum permissible defueling pressure.

(2)

Oil filler openings must be marked at or near the filler cover with the word “oil”.

(d)

Emergency exit placards. Each placard and operating control for each emergency exit must be red. A placard must be near each emergency exit control and must clearly indicate the location of that exit and its method of operation.

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-11, 41 FR 55471, Dec. 20, 1976]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-11, 41 FR 55471, Dec. 20, 1976]

§27.1559. Limitations placard.

14 C.F.R. § 27.1559

There must be a placard in clear view of the pilot that specifies the kinds of operations (such as VFR, IFR, day, night, or icing) for which the rotorcraft is approved.

Notes, amendments, and revision history

Amendments

[Amdt. 27-21, 49 FR 44435, Nov. 6, 1984]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Amdt. 27-21, 49 FR 44435, Nov. 6, 1984]

§27.1561. Safety equipment.

14 C.F.R. § 27.1561

(a)

Each safety equipment control to be operated by the crew in emergency, such as controls for automatic liferaft releases, must be plainly marked as to its method of operation.

(b)

Each location, such as a locker or compartment, that carries any fire extinguishing, signaling, or other life saving equipment, must be so marked.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

§27.1565. Tail rotor.

14 C.F.R. § 27.1565

Each tail rotor must be marked so that its disc is conspicuous under normal daylight ground conditions.

Notes, amendments, and revision history

Amendments

[Amdt. 27-2, 33 FR 965, Jan. 26, 1968]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Amdt. 27-2, 33 FR 965, Jan. 26, 1968]

§27.1581. General.

14 C.F.R. § 27.1581

(a)

Furnishing information. A Rotorcraft Flight Manual must be furnished with each rotorcraft, and it must contain the following:

(1)

Information required by §§ 27.1583 through 27.1589.

(2)

Other information that is necessary for safe operation because of design, operating, or handling characteristics.

(b)

Approved information. Each part of the manual listed in §§ 27.1583 through 27.1589, that is appropriate to the rotorcraft, must be furnished, verified, and approved, and must be segregated, identified, and clearly distinguished from each unapproved part of that manual.

(c)

[Reserved]

(d)

Table of contents. Each Rotorcraft Flight Manual must include a table of contents if the complexity of the manual indicates a need for it.

Notes, amendments, and revision history

Amendments

[Amdt. 27-14, 43 FR 2325, Jan. 16, 1978]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Amdt. 27-14, 43 FR 2325, Jan. 16, 1978]

§27.1583. Operating limitations.

14 C.F.R. § 27.1583

(a)

Airspeed and rotor limitations. Information necessary for the marking of airspeed and rotor limitations on, or near, their respective indicators must be furnished. The significance of each limitation and of the color coding must be explained.

(b)

Powerplant limitations. The following information must be furnished:

(1)

Limitations required by § 27.1521.

(2)

Explanation of the limitations, when appropriate.

(3)

Information necessary for marking the instruments required by §§ 27.1549 through 27.1553.

(c)

Weight and loading distribution. The weight and center of gravity limits required by §§ 27.25 and 27.27, respectively, must be furnished. If the variety of possible loading conditions warrants, instructions must be included to allow ready observance of the limitations.

(d)

Flight crew. When a flight crew of more than one is required, the number and functions of the minimum flight crew determined under § 27.1523 must be furnished.

(e)

Kinds of operation. Each kind of operation for which the rotorcraft and its equipment installations are approved must be listed.

(f)

[Reserved]

(g)

Altitude. The altitude established under § 27.1527 and an explanation of the limiting factors must be furnished.

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-2, 33 FR 965, Jan. 26, 1968; Amdt. 27-14, 43 FR 2325, Jan. 16, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-2, 33 FR 965, Jan. 26, 1968; Amdt. 27-14, 43 FR 2325, Jan. 16, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978]

§27.1585. Operating procedures.

14 C.F.R. § 27.1585

(a)

Parts of the manual containing operating procedures must have information concerning any normal and emergency procedures and other information necessary for safe operation, including takeoff and landing procedures and associated airspeeds. The manual must contain any pertinent information including—

(1)

The kind of takeoff surface used in the tests and each appropriate climbout speed; and

(2)

The kind of landing surface used in the tests and appropriate approach and glide airspeeds.

(b)

For multiengine rotorcraft, information identifying each operating condition in which the fuel system independence prescribed in § 27.953 is necessary for safety must be furnished, together with instructions for placing the fuel system in a configuration used to show compliance with that section.

(c)

For helicopters for which a VNE (power-off) is established under § 27.1505(c), information must be furnished to explain the VNE (power-off) and the procedures for reducing airspeed to not more than the VNE (power-off) following failure of all engines.

(d)

For each rotorcraft showing compliance with § 27.1353 (g)(2) or (g)(3), the operating procedures for disconnecting the battery from its charging source must be furnished.

(e)

If the unusable fuel supply in any tank exceeds five percent of the tank capacity, or one gallon, whichever is greater, information must be furnished which indicates that when the fuel quantity indicator reads “zero” in level flight, any fuel remaining in the fuel tank cannot be used safely in flight.

(f)

Information on the total quantity of usable fuel for each fuel tank must be furnished.

(g)

The airspeeds and rotor speeds for minimum rate of descent and best glide angle as prescribed in § 27.71 must be provided.

Notes, amendments, and revision history

Amendments

[Amdt. 27-1, 32 FR 6914, May 5, 1967, as amended by Amdt. 27-14, 43 FR 2326, Jan. 16, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Amdt. 27-1, 32 FR 6914, May 5, 1967, as amended by Amdt. 27-14, 43 FR 2326, Jan. 16, 1978; Amdt. 27-16, 43 FR 50599, Oct. 30, 1978; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984]

§27.1587. Performance information.

14 C.F.R. § 27.1587

(a)

The Rotorcraft Flight Manual must contain the following information, determined in accordance with §§ 27.49 through 27.87 and 27.143(c) and (d):

(1)

Enough information to determine the limiting height-velocity envelope.

(2)

Information relative to—

(i)

The steady rates of climb and descent, in-ground effect and out-of-ground effect hovering ceilings, together with the corresponding airspeeds and other pertinent information including the calculated effects of altitude and temperatures;

(ii)

The maximum weight for each altitude and temperature condition at which the rotorcraft can safely hover in-ground effect and out-of-ground effect in winds of not less than 17 knots from all azimuths. These data must be clearly referenced to the appropriate hover charts. In addition, if there are other combinations of weight, altitude and temperature for which performance information is provided and at which the rotorcraft cannot land and take off safely with the maximum wind value, those portions of the operating envelope and the appropriate safe wind conditions must be stated in the Rotorcraft Flight Manual;

(iii)

For reciprocating engine-powered rotorcraft, the maximum atmospheric temperature at which compliance with the cooling provisions of §§ 27.1041 through 27.1045 is shown; and

(iv)

Glide distance as a function of altitude when autorotating at the speeds and conditions for minimum rate of descent and best glide as determined in § 27.71.

(b)

The Rotorcraft Flight Manual must contain—

(1)

In its performance information section any pertinent information concerning the takeoff weights and altitudes used in compliance with § 27.51; and

(2)

The horizontal takeoff distance determined in accordance with § 27.65(a)(2)(i).

Notes, amendments, and revision history

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-14, 43 FR 2326, Jan. 16, 1978; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984; Amdt. 27-44, 73 FR 11000, Feb. 29, 2008; 73 FR 33876, June 16, 2008; Amdt. 27-51, 88 FR 8739, Feb. 10, 2023]

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.

Amendments

[Doc. No. 5074, 29 FR 15695, Nov. 24, 1964, as amended by Amdt. 27-14, 43 FR 2326, Jan. 16, 1978; Amdt. 27-21, 49 FR 44435, Nov. 6, 1984; Amdt. 27-44, 73 FR 11000, Feb. 29, 2008; 73 FR 33876, June 16, 2008; Amdt. 27-51, 88 FR 8739, Feb. 10, 2023]

§27.1589. Loading information.

14 C.F.R. § 27.1589

There must be loading instructions for each possible loading condition between the maximum and minimum weights determined under § 27.25 that can result in a center of gravity beyond any extreme prescribed in § 27.27, assuming any probable occupant weights.

Notes, amendments, and revision history

Authority

Authority: 49 U.S.C. 106(f), 106(g), 40113, 44701-44702, 44704.

Source

Source: Docket No. 5074, 29 FR 15695, Nov. 24, 1964, unless otherwise noted.